Articles
All articles | Recent articles
Effects of NH4VO3 on Properties and Structures of Cordierite Ceramics
W. Ning, Z. Tang, Z. Han, S. Ding, C. Xu, P. Zhang
Key Laboratory of Automobile Materials of Ministry of Education and College of Materials Science and Engineering, Jilin University, Changchun 130025, China
received July 20, 2017, received in revised form September 25, 2017, accepted November 9, 2017
Vol. 9, No. 1, Pages 47-52 DOI: 10.4416/JCST2017-00063
Abstract
To obtain cordierite ceramics with superior properties, different proportions of NH4VO3 were added to a preferred basic ceramic formula, the main raw materials of which included talc, kaolin, calcined kaolin, alumina, aluminum hydroxide and amorphous SiO2. The cordierite ceramics were manufactured by means of high-temperature sintering. The results show that the coefficient of thermal expansion of the cordierite ceramics is significantly reduced with the addition of 4 % NH4VO3; water absorption rate, apparent porosity and flexural strength of the ceramics were increased. The results of FT-IR, XRD and SEM analyses show that V ion entered the lattice of the cordierite crystals and formed V-O bonds and V-O-Si bonds by replacing Mg2+ and Si4+, the strength of the chemical bonds was enhanced during the sintering process. The cell parameters of the cordierite were changed from a = 9.7638 Å, c = 9.3152 Å to a = 9.6851 Å, c = 9.2923 Å. The microcracks in the ceramics disappeared while the pores were increased and uniform. Because of this, the coefficient of thermal expansion is decreased, and the other properties of cordierite ceramics are increased.
Download Full Article (PDF)
Keywords
NH4VO3, cordierite, thermal expansion, structure
References
1 Al-Harbi, O.A., Ozgur, C., Khan, M.M.: Fabrication and characterization of single phase cordierite honeycomb monolith with porous wall from natural raw materials as catalyst support, Ceram. Int., 41, 3526 – 32, (2015).
2 Assebban, M., Tian, Z.-Y., El Kasmi, A., et al.: Catalytic complete oxidation of acetylene and propene over clay versus cordierite honeycomb monoliths without and with chemical vapor deposited cobalt oxide, Chem. Eng. J., 262, 1252 – 59, (2015).
3 Goren, R., Gocmez, H., Ozgur, C.: Synthesis of cordierite powder from talc, diatomite and alumina, Ceram. Int., 32, 407 – 09, (2006).
4 Kuscer, D., Bantan, I., Hrovat, M., et al.: The microstructure, coefficient of thermal expansion and flexural strength of cordierite ceramics prepared from alumina with different particle sizes, J. Eur. Ceram. Soc., 37, 739 – 46, (2017).
5 Njoya, D., Elimbi, A., Fouejio, D., et al.: Effects of two mixtures of kaolin-talc-bauxite and firing temperatures on the characteristics of cordierite-based ceramics, J. Build. Eng., 8, 99 – 106, (2016).
6 Sembiring, S., Simanjuntak, W., Situmeang, R., et al.: Preparation of refractory cordierite using amorphous rice husk silica for thermal insulation purposes, Ceram. Int., 42, 8431 – 37, (2016).
7 Valaskova, M.: Clays, clay minerals and cordierite ceramics – a review, Ceram.-Silikaty, 59, 331 – 40, (2015).
8 Valášková, M., Martynková, G.S., Smetana, B., et al.: Influence of vermiculite on the formation of porous cordierites, Appl. Clay Sci., 46, 196 – 201, (2009).
9 Wang, W.B., Shi, Z.M., Wang, X.G., et al.: The phase transformation and thermal expansion properties of cordierite ceramics prepared using drift sands to replace pure quartz, Ceram. Int., 42, 4477 – 85, (2016).
10 A Hamzawy, E.M., Bin Hussain, M.A.: Sintered gahnite-cordierite glass-ceramic based on raw materials with different fluorine sources, Bull. Mater. Sci., 38, 1731 – 36, (2015).
11 Kumar, M.S., Perumal, A.E., Vijayaram, T.R., et al.: Processing and characterization of pure cordierite and zirconia-doped cordierite ceramic composite by precipitation technique, Bull. Mater. Sci., 38, 679 – 88, (2015).
12 Liu, Y., Luo, F., Su, J.B., et al.: Dielectric and microwave absorption properties of Ti3SiC2/cordierite composite ceramics oxidized at high temperature, J. Alloy. Compd., 632, 623 – 28, (2015).
13 Naga, S.M., Sayed, M., Elmaghraby, H.F., et al.: Fabrication and properties of cordierite/anorthite composites, Ceram. Int., 43, 6024 – 28, (2017).
14 Xu, X., Zhang, Y., Wu, J., et al.: Preparation and performance study of cordierite/mullite composite ceramics for solar thermal energy storage, Int. J. Appl. Ceram. Tec., 14, 162 – 72, (2017).
15 Zhang, L.F., Olhero, S., Ferreira, J.M.F.: Thermo-mechanical and high-temperature dielectric properties of cordierite-mullite-alumina ceramics, Ceram. Int., 42, 16897 – 905, (2016).
16 Banjuraizah, J., Mohamad, H., Ahmad, Z.A.: Thermal expansion coefficient and dielectric properties of non-stoichiometric cordierite compositions with excess MgO mole ratio synthesized from mainly kaolin and talc by the glass crystallization method, J. Alloy. Compd., 494, 256 – 60, (2010).
17 Banjuraizah, J., Mohamad, H., Ahmad, Z.A.: Densification and crystallization of nonstoichiometric cordierite glass with excess MgO synthesized from kaolin and Talc: Densification and crystallization of nonstoichiometric cordierite glass, J. Am. Ceram. Soc., 94, 687 – 94, (2011).
18 Ohsato, H., Kim, J.S., Cheon, C.I., et al.: Crystallization of indialite/cordierite glass ceramics for millimeter-wave dielectrics, Ceram. Int., 41, S588 – S93, (2015).
19 Xu, X.Y., Xu, X.H., Wu, J.F., et al.: Fabrication and characterization of cordierite-based glass-ceramic adhesives for bonding solar heat transmission pipelines, Ceram. Int., 43, 149 – 56, (2017).
20 Malekzadeh, H., Rezvani, M.: Sol-gel derived cordierite glass-ceramic doped CaO and B2O3: Sintering, crystallization and phase transformation characteristics, J. Sol-Gel Sci. Technol., 68, 128 – 35, (2013).
21 Wu, J.M., Hwang, S.P.: Effects of (B2O3, P2O5) additives on microstructural development and phase – transformation kinetics of stoichiometric cordierite glasses, J. Am. Ceram. Soc., 83, 1259 – 65, (2000).
22 Clark, S.M.: The kinetic analysis of irreversible consecutive solid state reactions: The effect of zinc on the formation of cordierite, J. Am. Ceram. Soc., 100, 2525 – 32, (2017).
23 Ogiwara, T., Noda, Y., Shoji, K., et al.: Low temperature sintering of [alpha]-cordierite ceramics with low thermal expansion using Li2O-Bi2O3 as a sintering additive, J. Ceram. Soc. Jpn., 119, 706, (2011).
24 Fu, P., Huang, Z., Zhang, F.: A study on preparation of cordierite porous ceramics made from starch Pore-forming agent, Chem. Eng. Mater. Prop. II, 549, 563 – 66, (2012).
25 Li, Y., Cao, W., Gong, L.L., et al.: Effect of starch on sintering behavior for fabricating porous cordierite ceramic, High Temp. Mater. Proc. (London), 35, 955 – 61, (2016).
26 Sandoval, M.L., Talou, M.H., Martinez, A.G.T., et al.: Starch consolidation casting of cordierite precursor Mixtures: Rheological behavior and green body properties, J. Am. Ceram. Soc., 98, 3014 – 21, (2015).
27 Zhu, K., Yang, D., Wu, J., et al.: Synthesis of cordierite with low thermal expansion coefficient, Chinese Ceram. Commun., 105 – 106, 802 – 04, (2010).
28 Li, Y.L., Liu, J., Hu, H., et al.: Effects of potassium and sodium content on properties of cordierite honeycomb ceramic, in chinese, J. Synth. Cryst., 41, 183 – 187, (2012).
29 Hochella M.F., Brown G.E.: Structural mechanisms of anomalous thermal expansion of cordierite-beryl and other framework silicates, J. Am. Ceram. Soc., 69, 13 – 18, (1986).
30 Ikawa, H., Otagiri, T., Imai, O., et al.: Crystal structures and mechanism of thermal expansion of high cordierite and its solid solutions, J. Am. Ceram. Soc., 69, 492 – 98, (1986).
31 Predecki, P., Haas, J., Faber, J., et al.: Structural aspects of the lattice thermal expansion of hexagonal cordierite, J. Am. Ceram. Soc., 70, 175 – 82, (1987).
Copyright
Göller Verlag GmbH